KGnmarGOwnersManualFOR POTABLE WATER HEATING ONLY NOT SUITABLE FOR SPACE HEATINGNOT FOR USE !N MOBILE HOMESMODEL NUMBERS:IS3.33286I 40Gal.LR ! S3.3328
Installation Instructions (cont’d)Facts to Consider About the Location (cont’d)A WARNINGThis water heater must not be installed directly o
Installation Instructions (cont’d)POWER VENT TERMINAL24"7= NATURAL DRAFT (GRAVITY),i... X / DIRECT VENT, POWER VENT----------H ( ')) / OR
1. when directly coinrnunicating with the outdoors, each opening shall have a minimum free area of 1 square inch per 4,000 BTU per hour of total inpu
Installation Instructions (cont’d)Water Piping’XA WARNINGHOTTER WATER CAN SCALD; Water heaters are intended to produce hot water. Water heated to
Installation Instructions (cont’d)Temperature-Pressure Relief ValveA WARNINGAt the time of manufacture this water heater was provided with a
Installation Instructions (cont’d)Filling the Water HeaterA CAUTIONNever use this water heater unless it is completely filled with water. T
Wiring (cont’d)USE WITHOUT POWER CORD (cont’d)Installation Instructions (cont’d)3- A standard 'A" conduit opening has been made in the water
Installation Instructions (cont’d)VentingA WARNINGTo insure proper venting of this gas*fired water heater, the correct vent pipe diameter
Installation Instructions (cont’d)Venting (cont’d)ALL MODELS — OPTIONAL 2" VENT PIPING2" PVC, ABS or CPVC Schedule 40 vent piping:1. A wir
Installation Instructions (cont’d)ALL MODELS — VENTING THROUGH WALL OPTIONAL r VENT PIPING2" DIA.VENT MAX. LENGTH fFT.)NUMBER OF 90° DEG. ELBOWS*
Safety Precautions^WARNINGimproper installation, adjustment, alteration, service or maintenance can cause DEATH, SERIOUS BODILY INJURY, OR
Installation Instructions (cont’d)Venting (cont’d)VENTING THROUGH AN OUTSIDE WALL WITH LOW GROUND CLEARANCE1. When the vent piping cannot pass
Installation Instructions (cont’d)APPROXIMATE SETTING TIME FOR 2"TO 3" PIPE JOINTSMOVEMENT COMPLETEOF JOINT SET90°Fto ISO-FVi hr.8 hrs
Installation Instructions (cont’d)Venting (cont’d)VENTING THROUGH A ROOFALL MODELS3" PVC, ABS or CPVC Schedule 40 vent piping:1. A 3" PVC
Installation Instructions (cont’d)ALL MODELS —THROUGH ROOF3 " DIA. VENT NUMBER OF 90° DEG.MAX. LENGTH fFT.)ELBOWS*1 1511 10 2105 3100 495 590 6AL
Installation Instructions (cont’d)Gas Piping (cont’d)A WARNINGThe appliance and its individual shutoff valve must be disconnected from the
Installation ChecklistBEFORE OPERATING:• Check the gas lines for leaks.a. Use a soapy water solution. DO NOT test for gas leaks using a match or ope
Operating InstructionsThis water heater is equipped with an electrically operated venting system and electronic control. For the burne
Operating Instructions (cont’d)OperatingA WARNINGBEFORE OPERATING [PROPANE (L.P.) GAS WATER HEATERS]: Propane (L.P.) gas is heavier than ^r
Operating Instructions (cont’d)FOR YOUR SAFETY READ BEFORE OPERATING®AWARNING: if you do not follow these instructions exactly, a fire or explosi
Operating Instructions (cont’d)Temperature RegulationShort repeated heating qrcles caused by small hot water uses can cause temperatures at t
Safety Precautions (cont’d)AWARNINGAWARNINGA gas water heater cannot operate properly without the correct amount of air for combustion.
Service and AdjustmentTank (Sediment) CleaningSediment build-up on the tank bottom may create varying amounts of noise, and if left in the tan
Service and Adjustment (cont’d)Temperature-Pressure Relief Valve OperationThe temperature-pressure relief vaive must be manually operated at l
Start Up ConditionsTHERMAL EXPANSIONTroubleshootingWater supply systems may, because of such events as high line pressure, frequent cut-of
TroubleshootingCONDENSATIONwhenever the water heater is filled with cold water, a certain amount of condensation will form while the
Operational Conditions (cont’d)VENTING MANUAL RESET SWITCHThere is a venting manual reset switch located on the draft hood. If the switch
Leakage CheckpointsUse this guide to check a “Leaking” water heater. Many suspected “Leakers” are not leaking tanks. Often the source
Troubleshooting Gi• iB (cont’d)A WARNINGA CAUTIONThis ^ubieshooting guide has been supplied for use by quali* fled service personnel who h
Troubleshooting(cont’d)SYSTEMS CHECKPlease check guidelines below. For your safety, water heater service should be performed only by a qualified servi
Troubleshooting(cont’d)PROBLEM CAUSE SOLUTIONNOT ENOUGH HOT WATERBlower will not run. |A) “ON/OFF” control switch turned off. Turn switch to the “ON”
Notes39
Safety Precautions (cont’d)A WARNINGMinimum clearances between the water heater and combustible construction are 0" at the sides a
Parts Order ListTHE ECONOMIZER™ 6 POWER VENT GAS WATER HEATER MODEL NUMBERS: 153.332861 40 Gal. L.P.153.332870HA 40 Gal. High Altitude L.P.153.332
THE ECONOMIZER™ 6 POWER VENT GAS WATER HEATER MODEL NUMBERS: 153.332861 40 Gal. L.P.153.332870HA 40 Gal. High Altitude L.P.153.332880 50 Gal. L.P.1
Parts Order ListTHE ECONOMIZER™ 6 POWER VENT GAS WATER HEATER MODEL NUMBERS: 153.332960 40 Gal.153.332970HA 40 Gal. High Altitude153.332980 50 Gal
THE ECONOMIZER™ 6 POWER VENT GAS WATER HEATER MODEL NUMBERS: 153.332960 40 Gal.153.332970HA 40 Gal. High Altitude153.332980 50 Gal.I53.33299OHA 50
FULL ONE YEAR mRJUNTY ON WATER HEAFERFor one year from the dace of purchase, when your Sears Kenmore water heater is installed and operated in a singl
Table of ContentsSafety Precautions...2-4labié of Contents...
Customer ResponsibilitiesThank You for purchasing a Sears water heater. Properly installed and maintained, it should give you years of
Materials and Basic Tools NeededMaterials NeededTo simplify the installation Sears has available the installation parts shown below. You may o
Installation InstructionsRemoving the Old Water Heater© luFii “OFF” the gas supply to the water heater.©AWARNINGIf the main gas line shutoff ser
A CAUTIONFacts to Consider About the LocationYou shouid carefully choose an indoor location for the new water heater, because the placement is
Kommentare zu diesen Handbüchern